McCulloch Trimmer problems

21 years ago

I have a very old (13+years) McCulloch trimmer and it still ran pritty good until a little while ago it doesn't accellerate good and for most of the time it runs best at half choke when i take choke off and go to squeeze the throttle it bogs down then slowly gets up to full throttle it never did this before. Any ideas of what a problem could be?

Featured Answer

dock

10 years ago

McCulloch has been split up and in Australia the name is owned by Electrolux but I have seen Poulan and Husqvrana chain Saws re badged as McCulloch. What appears to be the original designed McCulloch is made in China and is sold under a different name.

So to answer richibaby all I can suggest is that you hunt around and see if you can Identify the name of the original manufacturer and go from there.

Kyle without seeing your Trimmer I can only say that depending on the amount of fuel it is spraying out the exhaust it is either flooded in which a clean out is all that is needed, alternatively you could have a blocked air inlet or filter causing it to draw in to much fuel or as you suggest you need a Carby rebuild. I do not know if you have fuel with a percentage of ethanol in it, but if you do, do not use it in small petrol powered appliances as the ethanol attacks the diaphragms and gaskets in the carby.

Sort by:Oldest

Comments (11)

gorper99
21 years ago
See post below yours(Echo)
nor_easter
21 years ago
mmlawn,

Did you solve the problem with your trimmer? Was it a kinked or worn fuel-line as described in the echo thread? I ask because my trimmer (a McCulloch "Roadrunner" now 15+ yrsold)is having the same problems halfway through this season and it has always been a strong runner.
Related Professionals
Mobile Landscape Architects & Landscape Designers · Platteville Landscape Architects & Landscape Designers · Las Cruces Landscape Architects & Landscape Designers · Emporia Landscape Contractors · Hopkinsville Landscape Contractors · Frederick Landscape Contractors · Hattiesburg Landscape Contractors · Roanoke Landscape Contractors · Elgin Landscape Contractors · Rutland Landscape Contractors · Mountain Home Tile and Stone Contractors · Grand Forks Tile and Stone Contractors · Concord Tile and Stone Contractors · Everett Tile and Stone Contractors · Lagrange Tile and Stone Contractors
mmlawn
Original Author
21 years ago
no, its working no better, the gas line is not kinked in fact it seems its getting too much fuel, if i squeeze the throttle it boggs down then slowly picks up or quits. i got it up to full throttle then i held it for a 10 min or so and it ran ok. I probably won't mess with it too much its old and i may just get a new one if i can get it working better
dock
21 years ago
Guys.
It sounds to me that for some reason your unit is running too lean.
1.
Check the fuel system to ensure it is ok and no blocked filters etc.

2.
Clean out the fuel tank and put some fresh fuel in it.

3.
If the above does not fix the problem adjust the jets in the carburettor. It is possible that with all this pollution stuff happening that the formulation of the fuel you are using has changed causing the unit to change tune.

4.
Always use the same brand of fuel.

Dock.
dustyol2stroke
20 years ago
An adjustment probably won't be strong enough on a trimmer that old. You should look in to rebuilding the carb. The kit will cost around $11 retail and takes less than 1/2 hr even if you don't know what you are doing. A shop would probably charge you $40 like I used to, lol.
avid12
19 years ago
Just bought a used trimmer, seems to be around 5 yrs old. Gas was leaking out where fuel line enters tank. Pulled it and line broke off at tank. Do I need a new tank?
Thanks!
richibaby_hotmail_com
15 years ago
I need a Throttle cable for Mcculloch Roadrunner trimmer; can someone help me?
Kyle Ireland
10 years ago
I have a McCulloch roadrunner trimmer and when I try to start it it sprays fuel out the exhaust. Any suggestions??? I suspect a carburetor rebuild is the answer but not sure if something else would cause this as well.
Kyle Ireland
10 years ago
Thank you dock for your help on this. It is not spraying a heap of fuel but does spray every time cord is pulled, probably enough to cover our palm if you held in front of exhaust. I've pulled carby apart and gaskets & diaphragm looks good but from my experience you can't be sure until you've changed them. I think I'll rebuild it n see what happens. Thanks again mate, your input was helpful & appreciated
Brian Elsworth
5 years ago
WHEN THE ENGIN IS RUNNING THE SPINDEL WHERE THE LINE COMES OUT DOSE NOT GO ROUND CAN ANYONE PLEASE ADVISE.THANKS.